Past two drives heater is not heating up, still blows but only freezing air! coolant level is fine and havent had any temp issues. Could this be a thermostat? or possibly a blockage in the heater system?
Charles
No hot air
-
Micron
- Site Admin
- Posts: 3392
- Joined: Thu Sep 06, 2018 6:08 pm
- Location: South Norfolk
- Has thanked: 62 times
- Been thanked: 90 times
Re: No hot air
as you say, it might be a stuck thermostat, it could be stuck open, or you may have an airlock, try having the car tick over and warm up with the cap on the engine removed, heater on full.
Admin and Owner of this fine club 
Location : South Norfolk
Location : South Norfolk
-
CharlesUK
- Full Member
- Posts: 99
- Joined: Mon Feb 14, 2022 10:55 am
- Location: Yeovil, Somerset
- Has thanked: 1 time
- Been thanked: 3 times
-
Micron
- Site Admin
- Posts: 3392
- Joined: Thu Sep 06, 2018 6:08 pm
- Location: South Norfolk
- Has thanked: 62 times
- Been thanked: 90 times
Re: No hot air
It's actually on the engine, but not the oil cap, it's a meatal cap, but it isn't sprung like a normal rad cap, that it the other one near the header tank.
Have you remove the one of the engine before?
Admin and Owner of this fine club
Location : South Norfolk
Location : South Norfolk
-
CharlesUK
- Full Member
- Posts: 99
- Joined: Mon Feb 14, 2022 10:55 am
- Location: Yeovil, Somerset
- Has thanked: 1 time
- Been thanked: 3 times
Re: No hot air
thanks, just removed it and let it run for a couple of minutes. The air is hot again!Micron wrote: ↑Mon Feb 26, 2024 5:11 pmIt's actually on the engine, but not the oil cap, it's a meatal cap, but it isn't sprung like a normal rad cap, that it the other one near the header tank.
Have you remove the one of the engine before?
Charles
-
Micron
- Site Admin
- Posts: 3392
- Joined: Thu Sep 06, 2018 6:08 pm
- Location: South Norfolk
- Has thanked: 62 times
- Been thanked: 90 times
Re: No hot air
Check the water level once it has cooled down, and top it up to the brim, you may need to remove the other cap too, but replace the one near the header tank first.
Admin and Owner of this fine club
Location : South Norfolk
Location : South Norfolk
-
Sunfly
- Full Member
- Posts: 1033
- Joined: Fri Sep 07, 2018 9:11 am
- Location: Minchinhampton Glos
- Been thanked: 23 times
Re: No hot air
Hi Charles.
Very familiar problem to me on my 16v. I dont know if you can get the same issue on a 24v, but the problem was the heater was air locked. You can have a full radiator and everything working fine but no heat. The fix is to disconnect one of the heater hoses, connect a garden hose and push the air out via the radiator cap. Worked a treat. Cant remember the exact way I did it but I must have plugged the open end where you remove the hose or fit a vent pipe to above the rad cap. That done and the heater tested, dont forget the antifreeze.
Very familiar problem to me on my 16v. I dont know if you can get the same issue on a 24v, but the problem was the heater was air locked. You can have a full radiator and everything working fine but no heat. The fix is to disconnect one of the heater hoses, connect a garden hose and push the air out via the radiator cap. Worked a treat. Cant remember the exact way I did it but I must have plugged the open end where you remove the hose or fit a vent pipe to above the rad cap. That done and the heater tested, dont forget the antifreeze.
-
CharlesUK
- Full Member
- Posts: 99
- Joined: Mon Feb 14, 2022 10:55 am
- Location: Yeovil, Somerset
- Has thanked: 1 time
- Been thanked: 3 times
Re: No hot air
Once again no hot air! Have been losing coolant throughout the year, but can’t seem to get hot air even after filling and letting run with cap off. Expect heater is blocked as when recirculating the air it slowly warms itself up meaning the heater setting is on? Where abouts can I find the heater?
Charles
Charles
-
Micron
- Site Admin
- Posts: 3392
- Joined: Thu Sep 06, 2018 6:08 pm
- Location: South Norfolk
- Has thanked: 62 times
- Been thanked: 90 times
Re: No hot air
Behind the dash
Have you tried to flush the heater matrix with a hose, connect it straight to one of the pipes that comes from inside the car just in front of the passenger side in the engine bay and let it run out the other one.
Have you tried to flush the heater matrix with a hose, connect it straight to one of the pipes that comes from inside the car just in front of the passenger side in the engine bay and let it run out the other one.
Admin and Owner of this fine club
Location : South Norfolk
Location : South Norfolk
Who is online
Users browsing this forum: No registered users and 16 guests