Odd failures - fixed (partially)

For all technical questions. VIEWABLE without login, you need to register (free) to be able to post a question.
User avatar
Scooby
Registered User
Posts: 481
Joined: Fri Sep 21, 2018 11:49 am
Has thanked: 3 times
Been thanked: 3 times

Odd failures - fixed (partially)

Post by Scooby » Tue Apr 16, 2019 9:55 am

OK, so I have a series of "failures" which I noticed while replacing my stereo, and I figured someone might be able to help with.

I can only assume they're connected as they are so random, why wouldn't they be?
Everything (except rev counter) was working fine before I disconnected the original (after market) stereo.

1 - Rev counter not reading anything. (I noticed this before trying to replace my stereo but didn't think anything of it.)
2 - ACC 12v feed isn't working, with no apparent 12 on either side of the fuse.
3 - Electric mirror motors aren't working (not sure about heater part as I've not had call to use them).
4 - Electric aerial not working.

I replaced my dash (cosmetic reasons as well as hoping it might cure the ACC feed issue.)
While the dash was out, I replaced the little module thingy that I think is the rev counter circuit board on the clocks. No change.
Replaced the clock springs, and while my cruise control now works, it had no other effect.

All I can think is that they are all fed by a fuse or something that I don't know about. Can't see any blown fuses in the interior box other than the rear wiper which I replaced. However, the actual wiper and motor has been removed from the car so I'm not sure how that blew in the first place.

Any help gratefully received.
Last edited by Scooby on Thu May 02, 2019 2:40 pm, edited 1 time in total.
Member no: 227
Location: Banks, Nr Preston, Lancs.
Drives: 2x 24V - Japha and Chewie
Image

User avatar
Andy W
Full Member
Posts: 501
Joined: Thu Sep 06, 2018 11:49 pm
Has thanked: 1 time
Been thanked: 2 times

Re: Odd failures

Post by Andy W » Tue Apr 16, 2019 3:54 pm

Checked all the ones under the bonnet including the ones with the clear plastic lids?

User avatar
Scooby
Registered User
Posts: 481
Joined: Fri Sep 21, 2018 11:49 am
Has thanked: 3 times
Been thanked: 3 times

Re: Odd failures

Post by Scooby » Tue Apr 16, 2019 4:21 pm

Quick visual check only but none were labelled as being relevant.
Member no: 227
Location: Banks, Nr Preston, Lancs.
Drives: 2x 24V - Japha and Chewie
Image

mikenali
Registered User
Posts: 76
Joined: Mon Oct 22, 2018 12:31 pm
Been thanked: 1 time

Re: Odd failures

Post by mikenali » Wed Apr 17, 2019 8:53 am

If the 12v ACC feed isn't working, possibly a dodgy ignition switch.

User avatar
Scooby
Registered User
Posts: 481
Joined: Fri Sep 21, 2018 11:49 am
Has thanked: 3 times
Been thanked: 3 times

Re: Odd failures

Post by Scooby » Wed Apr 17, 2019 9:35 am

mikenali wrote:
Wed Apr 17, 2019 8:53 am
If the 12v ACC feed isn't working, possibly a dodgy ignition switch.
What else relies on the ACC position so I can eliminate that possibility? Unless of course everything is supplied from the same ACC circuit!
Member no: 227
Location: Banks, Nr Preston, Lancs.
Drives: 2x 24V - Japha and Chewie
Image

Micron
Site Admin
Posts: 3160
Joined: Thu Sep 06, 2018 6:08 pm
Has thanked: 52 times
Been thanked: 84 times

Re: Odd failures

Post by Micron » Wed Apr 17, 2019 11:26 am

Are any of them connected to the same earthing point? The other option is that there has to be a common point that they all start from, in a similar way that it could be a common earth?

Do you have the works manuals, that should you wiring diagrams that you could look at and follow to find the connection?
Admin and Owner of this fine club 😎

User avatar
Scooby
Registered User
Posts: 481
Joined: Fri Sep 21, 2018 11:49 am
Has thanked: 3 times
Been thanked: 3 times

Re: Odd failures

Post by Scooby » Wed Apr 17, 2019 12:02 pm

Don't have the manuals yet. Will be getting them at Beaulieu but was hoping to get this sorted before then.

Not sure if these items have any common points, I was hoping someone with much more experience / knowledge than me could answer that question.
Member no: 227
Location: Banks, Nr Preston, Lancs.
Drives: 2x 24V - Japha and Chewie
Image

Micron
Site Admin
Posts: 3160
Joined: Thu Sep 06, 2018 6:08 pm
Has thanked: 52 times
Been thanked: 84 times

Re: Odd failures

Post by Micron » Wed Apr 17, 2019 6:26 pm

It's a bit of an uncommon fault, which why people don't know, where as moby failures are two a penny, so everyone knows!
Admin and Owner of this fine club 😎

User avatar
Scooby
Registered User
Posts: 481
Joined: Fri Sep 21, 2018 11:49 am
Has thanked: 3 times
Been thanked: 3 times

Re: Odd failures

Post by Scooby » Thu Apr 18, 2019 11:04 am

You never know what people know until you ask the question, but I get your point.

Checked all fuses in the engine bay box and all are OK.

Does anyone know if any of the relays are involved in ACC supply?

Might be a relay problem.
Member no: 227
Location: Banks, Nr Preston, Lancs.
Drives: 2x 24V - Japha and Chewie
Image

Jon G 24V
Tech Rep
Posts: 658
Joined: Fri Sep 07, 2018 8:05 pm
Has thanked: 1 time
Been thanked: 6 times

Re: Odd failures

Post by Jon G 24V » Thu Apr 18, 2019 12:38 pm

Been looking at the Wiring Diagrams and have a Path for you to follow.

1) Check 60A Fuse in Battery Junction Box (IG KEY)
2) Power Feed to Ignition Switch should be Black / Blue Wire (Heavy Duty) Check at Connector under Dash and then again at Ignition Switch to ensure
you have 12V supply to Switch
3) Power from the Ignition Switch is on a Black and Pink Wire (Heavy Duty). Again check at Switch and then after Connector under Dash.
4) Turn Key to Position 2, dont start Car and try the Sunroof. This will tell you again if ACC has power.
5) Check METER Fuse in Footwell as the Clocks are supplied by this.
6) Mirrors run of the RADIO Fuse and the Stereo runs via METER, RADIO and ROOM Fuses so worth double checking these.

After this i'm lost :lol: :lol:

Post Reply

Who is online

Users browsing this forum: Google [Bot] and 50 guests